Page 1: Service Manual
SERVICE MANUAL CHASSIS MODEL COMMANDER DEST. CHASSIS NO. MODEL COMMANDER DEST. CHASSIS NO. KV-ES34M61 RM-916 Thailand SCC-U33B-A KV-ES34M61 RM-916 Malaysia SCC-U34A-A KV-ES34N90 RM-958 Taiwan SCC-P37B-A MUTING DISPLAY DRC-MF POWER MODE VIDEO JUMP ENTER TV/VIDEO FREEZE SWAP TWIN MENU PIP CH...
Page 2 CARBON PAINTED ON THE CRT, AFTER REMOVING THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE ANODE. THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. – 2 –...
Page 3 CARBON PAINTED ON THE CRT, AFTER REMOVING THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE ANODE. THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. – 3 –...
Page 4: Table Of Contents
KV-ES34M61/ES34N90 RM-916 RM-958 TABLE OF CONTENTS Section Title Page Section Title Page SELF DIAGNOSIS FUNCTION 6. DIAGRAMS ........ 5 6-1. Block Diagram ............95 1. GENERAL ................ 9 6-2. Frame Schematic Diagram ........113 Circuit Boards Location ........116 2. DISASSEMBLY 6-4.
Page 5: Self Diagnosis Function
KV-ES34M61/ES34N90 RM-916 RM-958 SELF DIAGNOSTIC FUNCTION The units in this manual contain a self-diagnostic function. If an error occurs, the STANDBY/TIMER lamp will automatically begin to flash. The number of times the lamp flashes translates to a probable source of the problem. A definition of the STANDBY/TIMER lamp flash indicators is listed in the instruction manual for the user’s knowledge and reference.
Page 6: Rm-916 Rm
KV-ES34M61/ES34N90 RM-916 RM-958 DISPLAY OF STANDBY/TIMER LIGHT FLASH COUNT 2 times 3 times Lamp ON 0.3 sec. Lamp OFF 3 sec. Lamp OFF 0.3 sec. 4 times 5 times 6 times 7 times STANDBY/SLEEP lamp Diagnostic Item Flash Count* +B overcurrent...
Page 7 KV-ES34M61/ES34N90 RM-916 RM-958 SELF-DIAGNOSTIC SCREEN DISPLAY For errors with symptoms such as “power sometimes shuts off” or “screen sometimes goes out” that cannot be confirmed, it is possible to bring up past occurances of failure for confirmation on the screen:...
Page 8 KV-ES34M61/ES34N90 RM-916 RM-958 SELF-DIAGNOSTIC CIRCUIT IC4301 IC001 IC003 RGB JUNGLE OVP OCP SYSTEM MEMORY FROM IKIN CRT (IK) [H] IC6801 XRAY [V] D6806/D6801 V PROT CXA2100Q IC004 MEMORY [+B overcurrent ªOCPº] Occurs when an overcurrent on the +B(135) line is detected by Q6610 and Q6609.
Page 9 AUDIO VIDEO DIGITAL IN (MONO) (DOLBY DIGITAL/PCM) VIDEO IN VIDEO OUT...
Page 10 (MONO) AUTO PROGR (MONO) AUTO AUTO PROGR PROGR DIGITAL IN (MONO) (DOLBY DIGITAL/PCM) PUSH PU SH …4 ≥ (MONO) AUTO PROGR...
Page 11 R-AUDIO-L VIDEO (MONO) LINE OUT DIGITAL IN (DOLBY DIGITAL/PCM) R-AUDIO-L VIDEO OPTICAL COAXIAL COMPONENT VIDEO OUT LINE OUT DIGITAL OUT S VIDEO OUT...
Page 12 DRC-MF MENU ENTER – – PROGR + JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER JUMP...
Page 13 MENU ENTER – – PROGR + DRC-MF JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR JUMP SOUND MODE MODE SURROUND ENTER PROGR FAVORITE INDEX PRESET VTR 1 2 3 DVD MENU PROGR ENTER DRC-MF PRESET VTR 1 2 3 DVD VIDEO TITLE PROGR +...
Page 14 SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD...
Page 15 DRC-MF JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR JUMP ENTER PRESET VTR 1 2 3 DVD SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER 1.PR 01 2.PR 03 3.PR 04 7.PR 12 6.PR 10 5.PR 08 4.PR 06...
Page 16 DRC-MF VIDEO TITLE PROGR + PROGR – SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER...
Page 17 JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD...
Page 18 DRC-MF DRC-MF JUMP JUMP SOUND SOUND MODE MODE SURROUND MODE MODE SURROUND PROGR FAVORITE INDEX PROGR FAVORITE INDEX...
Page 19 DRC-MF VIDEO TITLE PROGR + PROGR – SOUND MODE MODE SURROUND PROGR FAVORITE DRC-MF INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD JUMP P166 SECTEXT FR1 MAR 03:59:09 From Singapore Dep/Arr Flight Alrcraft To PARIS 220/0588 SQ28 2130/1225 PA115 2115/1330 SQ26...
Page 20 DRC-MF VIDEO TITLE PROGR + PROGR – SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD...
Page 22 SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER MU L T I P I C T URE PRESET VTR 1 2 3 DVD : OF F SWA P TW I N : OFF PROGRAM I NDE X MU L T I P I C T URE P I P OF F P I P POS I T I ON...
Page 23 MENU PROGR ENTER...
Page 24 DRC-MF VIDEO TITLE PROGR + PROGR – SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD...
Page 25 DRC-MF JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD...
Page 26 JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER...
Page 27 JUMP...
Page 28 PROGR FAVORITE INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD...
Page 32 DRC-MF PROGR JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX (MONO) MENU PROGR ENTER PRESET VTR 1 2 3 DVD DRC-MF VIDEO TITLE PROGR + PROGR – SOUND MODE MODE SURROUND PROGR FAVORITE INDEX...
Page 33 DRC-MF JUMP SOUND MODE MODE SURROUND PROGR FAVORITE INDEX MENU PROGR ENTER PRESET VTR 1 2 3 DVD DRC-MF VIDEO TITLE PROGR + PROGR – SOUND MODE MODE SURROUND PROGR FAVORITE INDEX...
Page 41: Service Jig
KV-ES34M61/ES34N90 SECTION 3 RM-916 RM-958 SERVICE JIG 3-1. JIGS REQUIRED FOR SERVICING REF NO. DESCRIPTION PART NO. REMARK TOOL (20P), SERVICE 3-702-763-01 For A to V board extension TOOL (40P), SERVICE 3-702-764-01 For A to E board extension TOOL (50P-A), SERVICE...
Page 42: Set-Up Adjustments
KV-ES34M61/ES34N90 SECTION 4 RM-916 RM-958 SET-UP ADJUSTMENTS • The following adjustments should be made when a complete Perform the adjustments in the following order : realignment is required or a new picture tube is installed. 1. Beam Landing • These adjustments should be performed with rated power 2.
Page 43 KV-ES34M61/ES34N90 RM-916 RM-958 4-2. CONVERGENCE ADJUSTMENT V. STAT Preparation : • Before starting this adjustment, adjust the focus, horizontal size and vertical size. • Set the Picture Mode to "STANDARD". • Cross hatch / Dot pattern. (1) Horizontal and Vertical Static Convergence H.
Page 44 KV-ES34M61/ES34N90 RM-916 RM-958 BMC (Hexapole) Magnet. (2) Dynamic Convergence Adjustment If the red, green and blue dots are not balanced or aligned, then Preparation: • use the BMC magnet to adjust in the manner described below. Before starting this adjustment, adjust the horizontal static convergence and the vertical static convergence •...
Page 45: Focus Adjustment
KV-ES34M61/ES34N90 RM-916 RM-958 (3) Screen-corner Convergence 4-3. FOCUS ADJUSTMENT Note Focus adjustment should be completed before W/B adjustment. (1) Receive digital monoscope pattern. (2) Set "A/V CONTROL" to "STANDARD". a-d : screen-corner (3) Adjust FOCUS VR so that the center of the screen becomes misconvergence justfocus.
Page 46: G2 (Screen) And White Balance Adjustments
KV-ES34M61/ES34N90 RM-916 RM-958 3. SUB PICTURE BRIGHTNESS ADJUSTMENT 4-5. G2 (SCREEN) AND WHITE BALANCE 1) Tune RF PAL white signal at program No. 1 and No. 2. ADJUSTMENTS 2) Select “TWIN PICTURE” mode. 3) Receive different RF PAL white signals in MAIN and Sub 1.
Page 47: Circuit Adjustments
KV-ES34M61/ES34N90 SECTION 5 RM-916 RM-958 CIRCUIT ADJUSTMENTS 5-1. ADJUSTMENTS WITH COMMANDER Service adjustments are made with the RM-916 and RM-958 that comes with this unit. 1, 4 Select the adjustment item. ↓ a. ENTERING SERVICE MODE 3, 6 Raise/lower the data value.
Page 48: Adjustment Method
KV-ES34M61/ES34N90 RM-916 RM-958 5-2. ADJUSTMENT METHOD Item Number 00 of device GEO Use the same method for all Items. Use 1 and 4 to select the This explanation uses H-Position as an example. 1. Select “GEO 00 VSZ” with the 1 and 4 buttons.
Page 61 KV-ES34M61/ES34N90 RM-916 RM-958 Abbreviation: Eco Mode V-Compressed Mode Non-Compressed Mode Surround VDD = Virtual Dolby Digital Virtual Dolby Prologic Tru Surround Simulated NOTE • shaded items are fixed data. • no data • Standard data listed on the Adjustment Item Table are reference values, therefore it may be different for each model and for each mode.
Page 62: Picture Quality Adjustments
PICTURE QUALITY : HI-FINE ECO MODE : OFF WIDE MODE : OFF VR1 - VR2 = 1.85 ± 0.07 (Vp-p) DRC-MF : DRC1250 (KV-ES34M61) DRC1050 (KV-ES34N90) (ii) SUB HUE/SUB COL Condition : INPUT SIGNAL Video Color Bar (White and Color 75%) HUO 7...
Page 63 KV-ES34M61/ES34N90 RM-916 RM-958 2. NTSC RF INPUT 3. PAL RF INPUT (KV-ES34M61 ONLY) Input signal ; NTSC RF color bar, 75%. Input signal ; PAL RF color bar, 75%. [TWIN] mode, [Service] mode. [TWIN] mode, [Service] mode. (i) SUB CONTRAST...
Page 64: Deflection Adjustments
Write “DAC 01 HLN DRC 100 Mode” as “DAC 01 HLN DRC Picture Mode to [DYNAMIC], Picture Rotation to [+/– 0] and 1250 Mode”. Eco Mode to OFF. 4. Set to DRC 1250 mode. (KV-ES34M61)/ FOR PIP MODE DRC 1050 mode. (KV-ES34N90) 15. Set to PIP mode.
Page 65: A Board Adjustment After Ic003 (Memory) Replacement
KV-ES34M61/ES34N90 RM-916 RM-958 5-5. A BOARD ADJUSTMENT AFTER IC003 (MEMORY) REPLACEMENT When replacing IC003 and IC004 (MEMORY), be sure to change IC001 (µ-COM) to the following at the same time. MODEL IC001 (µ-CON) KV-ES34M61 CXP750096-013Q KV-ES34N90 CXP750096-018Q 1. Enter to Service Mode.
Page 66: Picture Distortion Adjustment
KV-ES34M61/ES34N90 RM-916 RM-958 5-6. PICTURE DISTORTION ADJUSTMENT (1) PICTURE DISTORTION ADJUSTMENT (2) Item Number 00 – 0B H-TRAPEZOID (DAC 4 HTR) GEO 0 VSZ (V SIZE) GEO 1 VPS (V POSITION) GEO 2 VLN (V LINEARITY) GEO 3 SCO (VERTICAL S-Correction)
Page 67 KV-ES34M61/ES34N90 RM-916 RM-958 MEMO ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○...
Page 68 KV-ES34M61/ES34N90 RM-916 RM-958 MEMO ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○...
Page 69 KV-ES34M61/ES34N90 RM-916 RM-958 MEMO ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○...
Page 70 KV-ES34M61/ES34N90 RM-916 RM-958 MEMO ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○...
Page 71: Diagrams
KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 SECTION 6 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 DIAGRAMS 6-1. BLOCK DIAGRAM T6602 MAIN CONVERTER (CRT DRIVE) CN6800 V PROT VPROT Q6811, Q6819 Q6820, Q6821 ±17V RECT +17V AUDIO D6801 D6634 –17V AUDIO PUMP UP VSAW–...
Page 72 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 TO H2 BOARD TO H1/H3 BOARD TO J BOARD CN4101 CN4500 CN1934 CN1901/CN1980 CN8304 CN1195 CN1190 CN1180 EXTRA PARABOLA EXTRA-PARA R_OUT R OUT H DEFL HS_IN G_OUT G OUT...
Page 73 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 TO VM BOARD TO J BOARD TO A BOARD CN8301 CN1195 (TOP KEY) CN1980 CN1934 S1972 STBY TO A BOARD CN1190 KEY 1 OUT (LED, SIRCS RECEIVER) CN6101...
Page 74 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 IC802 IC602 CN8304 (YCT, COMB FILTER, (DRC, MID, DRC/MID CONTROLLER) 64Mbit SDRAM Y MAIN OUT 16Mbit SDRAM IC8306 VIDEO/AUDIO-IN/OUT) U MAIN OUT MAIN COLOR DECODER 2.5V 3.3V V MAIN OUT 2.5V...
Page 75 KV-ES34M61/ES34N90 RM-916 RM-958 – 111 –...
Page 76 KV-ES34M61/ES34N90 RM-916 RM-958 – 112 –...
Page 77: Circuit Boards Location
9V/12V :S-MICRO WHT-L tolerances. :S-MICRO :S-MICRO :S-MICRO • All voltages are in V. * V Board used for model KV-ES34M61 only Y100 Y-100 OUT CN5401 • : Cannot be measured. Note: The component identified by shading and U100 U-100 OUT •...
Page 78 :Pattern from the side which enables seeing. R037 220 :CHIP 27K :CHIP 220 :CHIP • :Pattern from the rear side. R049 39K :RN:CP A BOARD IC001 CXP750096-013Q (KV-ES34M61) R050 39K :RN:CP R100 100 :CHIP A BOARD IC001 CXP750096-018Q (KV-ES34N90) R102 100 :CHIP 100 :CHIP –...
Page 79: Schematic Diagram Of A Board
(1) Schematic Diagram of A Board TO SPEAKER CN1190 CN1138 CN1193 CN1195 :S-MICRO :S-MICRO TO MAGNETIC COIL :S-MICRO TO H1(CN1901)/ TO H3(CN1980) TO H2 BOARD CN1932 TO H2 BOARD CN1934 C1222 C1224 D012 6.3V 6.3V CN1161 PROTECTOR B:CHIP B:CHIP DIP PIN IC2600 D007 C1223...
Page 80: Schematic Diagram Of D Board
(2) Schematic Diagram of D Board CN6607 C6672 C6673 T6601 2200p 2200p R6660 TH6603 :FPRD M22007C IC6606 BA05T C6647 C6649 ST-BY 5V OUT D6619 D6616 D6617 C6635 D6623 D6628 ERC04-06S RD12ES-T1B 100p P6KE200AG23 ERC04-06S D1NL20U-TR STBY RECT C6630 18V CLAMP CLAMP DETECT RECT L6601...
Page 81 MARK LIST IC6805 E-6 D6620 D6809 D-10 IC6805 D-8 Q6821 D6631 B-10 D6825 IC6806 G-9 D6621 D6812 IC6806 F-5 Q6822 D6632 I-13 D6826 KV-ES34M61 KV-ES34M61 KV-ES34N90 D6622 D6813 Q6825 D6634 E-11 (Malaysia) (Thailand) (Taiwan) TRANSISTOR TRANSISTOR D6623 D6635 C-13 D6814 F-11 C6602 0.033 630V :PP...
Page 82: Schematic Diagrams Of D1 Board
(3) Schematic Diagram of D Board CN6104 CN6103 CN6102 WHITE :S-MICRO :S-MICRO TO VM BOARD TO RT COIL TO DY 135V C6352 6.5V IC6108 R6165 R6135 R6166 D6105 MB88141APF-ER RD2.7ESB2 DAC CONT :CHIP DC SHIFT R6163 R6164 M-PIN DF SW VSS1 VDD1 DF PH...
Page 83 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 PRINTED WIRING BOARD [DF, DQP DRIVE] – D1 Board – D1 BOARD WAVEFORMS 80Vp-p (H) 0.7Vp-p 352Vp-p 3.0Vp-p – 137 – – 138 –...
Page 84 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 PRINTED WIRING BOARDS [CRT DRIVE] [VM DRIVE] [AC LINE FILTER] – VM Board – – C Board – – F1 Board – – 139 – – 140 –...
Page 85: Schematic Diagrams Of C, F1 And Vm Boards
(4) Schematic Diagrams of C and VM Boards CN9007 R9055 C9034 820k 1/2W RV9002 CN1603 2.2M (AC LINE FILTER) R9058 :TAB NL9002 JW1602 820k JW1606 1/2W IC9001 TDA6111Q/N4 RED-VIDEO-OUT JW1601 JW1605 200V TO AC CORD L9001 RED.OUT C9032 CN1601 R9056 C9031 :LHL08 R9089...
Page 86: Schematic Diagram Of E Board
(5) Schematic Diagram of E Board L4312 +12V :CHIP +12V L4310 9V/12V C4335 C4337 :CHIP +12V +12V +12V D4311 CN4502 DAN202K R4313 R4338 C4316 4.7k L4301 :S-MICRO C4339 :CHIP D4313 C4333 L4302 L4305 :CHIP :CHIP CH:CHIP MA3062M-TX TO VM BOARD C4334 :CHIP :CHIP...
Page 87 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 PRINTED WIRING BOARDS [RGB OUT, DEFLECTION] – E Board (Component Side) – – E Board (Conductor Side) – E Board IC4301 CXA2100AQ 46 45 41 40 39 36 35 34 33 •...
Page 88 (6) Schematic Diagrams of H and H Boards CN1901 TO A BOARD TO A BOARD CN1190 CN1932 CN1195 TO A BOARD CN1934 :S-MICRO & CN1193 :S-MICRO TO J BOARD :S-MICRO CN8301 R1911 R1913 R1914 R1915 R1916 C1910 Q1901 Q1902 R1917 DTC144ESA DTC144ESA C1911...
Page 89 KV-ES34M61/ES34N90 RM-916 RM-958 PRINTED WIRING BOARDS [LED, SIRCS RECEIVER] [AV INPUT, PRESET KEY, PHONE OUT] [TOP KEY] – H1 Board – – H2 Board – – H3 Board – – 155 –...
Page 90 KV-ES34M61/ES34N90 RM-916 RM-958 B3 BOARD IC309, IC505 AND IC506 TC7SET04F (TE85R) NC 1 IN A 2 GND 3 OUT V B3 BOARD WAVEFORMS 1.6Vp-p (H) 1.72Vp-p (H) 1.64Vp-p (H) 4.7Vp-p (V) 4.8Vp-p (V) 2.3Vp-p (V) 2.2Vp-p (V) 2.8Vp-p (V) 3.1Vp-p (V)
Page 91 (7) Schematic Diagram of B (1/6) Board V PULSE H PULSE IC506 TC7SET04F(TE85R) A5V-1 LEVEL SHIFT R998 L511 R527 WSYNC R557 XRST5 :CHIP Q520 :CHIP DTC144EKA :CHIP :CHIP HP 100 OUT MID BUSY MID BUSY YMCK D3.3V L503 FL504 R598 CKD510JB1A105ST R501 FB503...
Page 92 (8) Schematic Diagram of B (2/6) Board PRINTED WIRING BOARDS [DRC, MID, DRC/MID CONTROLLER] IVDD Q601 3.3VGR IVDD ADTB 2SC2412K-T-146-Q IHDD R687 IHDD C639 – B3 Board (Component Side) – L604 C638 W13ID 0.01 0.01 W13ID C601 VP MAIN IN B:CHIP C637 FL601...
Page 93: Schematic Diagram Of B3 (3/6) Board
(9) Schematic Diagram of B (3/6) Board C717 C718 FL704 A3.3V C719 C716 R710 XRST C726 C725 C724 C723 C722 C738 SDA6 SDA5 VOUT35 SDA4 VOUT34 VOUT33 C715 SDD18 VOUT32 SDD19 SDD110 VOUT31 C727 SDD111 VOUT30 VOUT29 SDD112 VOUT28 SDD113 SDD114 VOUT27 IC704...
Page 94 (10) Schematic Diagram of B (4/6) Board VDOCRCLVL VDOCBCLVL VDOYCLVL BLK015A C823 R817 0.01 :RN-CP B:CHIP C824 C822 C821 0.01 0.01 0.01 B:CHIP B:CHIP B:CHIP R939 VDOCIN7 SDADR3 VDOCIN6 SDDAT16 VDOCIN5 SDDAT17 VDOCIN4 SDDAT18 VDOCIN3 SDDAT19 C825 AVCCPLL 0.01 B:CHIP C820 0.01 AVSSPLL...
Page 95 (11) Schematic Diagram of B (5/6) Board B3 BOARD IC901 CXD2309Q D3.3V-MID (LSB) R0 4LSB'S Q904 CURRENT 2SK2036 R915 R952 R916 R914 R913 LEVEL SHIFT 2.2k 4.7k R951 4.7k CELLS :CHIP :CHIP 2.2k :CHIP :CHIP SDA-MID 6LSB'S R917 LATCHES R944 DECODER CURRENT :CHIP...
Page 96 (12) Schematic Diagrams of B (6/6) and F Boards CN1651 CN1652 D301 D302 IC311 TO D BOARD TO F1 BOARD MA113-(TX) MA113-(TX) TAZ8L005AP-TPF6 CN6604 CN1602 L302 :CHIP C325 C332 C341 0.01 0.01 0.01 R334 B3 BOARD IC302 CXD2303AQ C319 B:CHIP B:CHIP B:CHIP C361...
Page 97: Schematic Diagram Of Dh Board
KV-ES34M61/ES34N90 RM-916 RM-958 (13) Schematic Diagram of DH Board PRINTED WIRING BOARDS [AC SWITCH] [MAGNETIC FIELD CORRECTION] IC3807 SENSOR UNIT – F2 Board – 12.2 C3801 X OUT IC3805 N/S DRIVE Q3811 R3846 BUFFER C3805 R3805 R3847 R3807 R3804 D3809...
Page 98 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 PRINTED WIRING BOARDS [AUDIO DSP] – A1 Board (Component Side) – – A1 Board (Conductor Side) – A1 Board IC8103 AK4524 AINL DGND DATT AINR LRCK Audio I/F BICK Controller SDTO...
Page 99: Schematic Diagrams Of A1 And E2 Boards
(14) Schematic Diagrams of A1 and E2 Boards A1 BOARD IC8105 TC9446F-002 Program Timing SCKO IC8104 S-80827ANUP-EDQ- FL8100 C8147 +5.0V-AU 4kword x 3 SCKI RESET FB8109 FB8110 C8168 Address Operator :CHIP 1.1UH X8102 C8108 C8117 :CHIP 18.432MHz B:CHIP :CHIP DLON C8112 C8129 B:CHIP...
Page 100: Schematic Diagrams Of Bc4 And V Boards
(15) Schematic Diagrams of BC4 and V Boards R1835 R1838 Q1804 :CHIP R1813 2SA1037 :CHIP R BUFFER R1814 R1819 :RN-CP C1818 R2113 R1839 R1836 :CHIP :CHIP :CHIP IC1801 :CHIP :CHIP SDA5254-2 R1841 R1818 4.7k TELEDECODER C1817 (Y/C SEP) :CHIP R1811 Q1805 :CHIP :CHIP...
Page 101 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 PRINTED WIRING BOARD [Y/C SEP] [AFC RASTER DISTORTION CIRCUIT] [TELETEXT] – V Board – (KV-ES34M61 only) V BOARD IC1801 SDA5254-2B006 – BC4 Board – Capture Compare Timer Display Timing Display VTX, VPS Watchdog...
Page 102 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 KV-ES34M61/ES34N90 RM-916 RM-958 RM-916 RM-958 RM-916 RM-958 J Board IC8302 CXA2069Q J Board IC8306 CXA2123AQ-T6 J BOARD WAVEFORMS 1.1Vp-p (H) 2.4Vp-p (H) 1.6Vp-p (H) 2.2Vp-p (H) 1.8Vp-p VOUT1 YIN1 YOUT1 TRAP1 1.1Vp-p (H) 1.2Vp-p (H) 1.3Vp-p (H) 2.1Vp-p (H) 0.3Vp-p (H)
Page 103: Schematic Diagram Of J Board
(16) Schematic Diagram of J Board PRINTED WIRING BOARDS [YCT, AUDIO DSP, COMB FILTER, VIDEO/AUDIO-IN/OUT] IC8313 IC8314 – J Board (Component Side) – BC4 COMPL R8362 CVBS :CHIP APCN R8592 CN8302 :TAB MAIN-C2 COMB RESET R8353 :CHIP R8512 C8348 R8354 :CHIP C8468 MAIN-CV2...
Page 104: Semiconductors
6-5. SEMICONDUCTORS DIODE TRANSISTOR 2SK2036(TE85L) CA0005AD AK4524 TA7805S MB94918-AG3MID CXD2303AQ D1NS4 D1NL20U-TR S3L20UF4 DTA144EKA-T146 2SK2251-01-F19 UPC1093J-1-T CXD9509Q PQ1CG2032FZ CXA2123AQ-T6 DM-58 BA05FP-E2 CA0007AD LF50CDT-TR ERA38-06 DTC114EK NJM3404AD BA05T ERA85-009 CATHODE 2SA1037AK-T146-R MM1115XFBE MARKING SIDE VIEW TOP209P NJM4560M RD10ESB2 2SA1162-G UPC393C TC7WU04F RD12ES-B2 2SA1776TV2Q UPC358C...
Page 105: Exploded Views
KV-ES34M61/ES34N90 SECTION 7 RM-916 RM-958 EXPLODED VIEWS NOTE: • • Items marked " ∗ " are not stocked since Items with no part number and no The components identified by description are not stocked because they are seldom required for routine...
Page 106: Chassis
* A-1342-535-A V BOARD MOUNTED (Thailand) ! 4-022-115-31 HOLDER, AC CORD (Thailand) ! 1-791-439-11 CORD, POWER (WITH CONNECTOR)(Malaysia) * A-1342-528-A V BOARD MOUNTED (Malaysia) 1-790-082-11 CABLE, RF (KV-ES34M61) ! 1-792-065-11 CORD, FILTER WITH POWER (Thailand, Taiwan) 1-792-458-11 CABLE, RF (KV-ES34N90) * 4-071-315-01 BRACKET, TERMINAL...
Page 107: Picture Tube
* 4-071-311-02 HOLDER, H3 ! 8-735-062-05 PICTURE TUBE (A80LNH10X) (KV-ES34N90) X-4037-420-1 FRAME SUB ASSY, TOP (Malaysia, Thailand) ! 8-735-063-05 PICTURE TUBE (A80LNH10X) (KV-ES34M61) 4-046-600-01 SPACER, DY (Taiwan, Malaysia) X-4037-510-1 FRAME SUB ASSY, TOP (Taiwan) X-4037-421-1 FRAME SUB ASSY, BOTTOM 4-046-818-01...
Page 108: Electrical Parts List
KV-ES34M61/ES34N90 SECTION 8 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. ELECTRICAL PARTS LIST Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK NOTE: • Items marked " ∗ " are not stocked since they •...
Page 109 DIODE RD5.6SB3-T1 D014 8-719-073-01 DIODE MA111-TX C2603 1-126-933-11 ELECT 100UF 20.00%16V C2605 1-126-925-11 ELECT 470UF 20.00%10V D100 8-719-073-01 DIODE MA111-TX (KV-ES34M61) C2606 1-164-344-11 CERAMIC CHIP 0.068UF 10.00%25V D300 8-719-073-01 DIODE MA111-TX C2608 1-126-916-11 ELECT 1000UF 20.00%6.3V D301 8-719-073-01 DIODE MA111-TX...
Page 110 1-236-071-11 ENCAPSULATED COMPONENT <IC LINK> <IC> PS1201 1-532-686-21 LINK, IC 2.7A/150V PS1202 1-532-686-21 LINK, IC 2.7A/150V IC001 8-752-910-27 IC CXP750096-013Q (KV-ES34M61) PS1203 1-532-686-21 LINK, IC 2.7A/150V IC001 8-752-913-11 IC CXP750096-018Q (KV-ES34N90) PS1204 1-532-686-21 LINK, IC 2.7A/150V IC002 8-759-042-02 IC S-80743AL-A7-T1...
Page 111 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R017 1-216-049-91 RES-CHIP 1/10W R068 1-216-073-00 RES-CHIP...
Page 112 1-216-037-00 RES-CHIP 1/10W <TUNER> R1261 1-216-037-00 RES-CHIP 1/10W R1264 1-216-041-00 RES-CHIP 1/10W TU101 8-598-452-20 TUNER, FSS BTF-WG442 (KV-ES34M61) R1265 1-216-041-00 RES-CHIP 1/10W TU101 8-598-477-10 TUNER, FSS BTF-WG411 (KV-ES34N90) R1266 1-216-049-91 RES-CHIP 1/10W TU3301 8-598-508-10 TUNER, FSS BTF-LG436 (KV-ES34M61) TU3301 8-598-476-00...
Page 113 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C8116 1-164-161-11 CERAMIC CHIP 0.0022UF 10.00%50V <CONNECTOR>...
Page 114 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK <RESISTOR> * A-1136-086-A B3 BOARD COMPLETE (Thailand)
Page 115 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C517 1-163-021-91 CERAMIC CHIP 0.01UF 10.00%50V C624...
Page 116 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C848 1-163-017-00 CERAMIC CHIP 0.0047UF 10.00%50V FL512...
Page 117 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK L604 1-412-029-11 INDUCTOR CHIP 10UH R338 1-216-295-91...
Page 118 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R576 1-208-756-11 METAL CHIP 0.5% 1/10W R661...
Page 119 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R840 1-216-295-91 SHORT R901 1-216-061-00 RES-CHIP 3.3K...
Page 120 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R993 1-216-089-91 RES-CHIP 1/10W <CRYSTAL> R994 1-216-033-00...
Page 121 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C2064 1-163-031-11 CERAMIC CHIP 0.01UF L2008 1-412-058-11...
Page 122 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R2057 1-216-049-91 RES-CHIP 1/10W <CAPACITOR> R2058 1-216-057-00 RES-CHIP 2.2K...
Page 123 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK <JACK> R9056 1-202-813-00 SOLID 1/2W R9057 1-202-847-00...
Page 124 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C6628 1-104-330-91 CERAMIC 470PF 10.00%1KV C6817 1-126-967-11...
Page 125 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C6882 1-104-574-11 CERAMIC 0.0047UF 10.00%2KV D6628 8-719-063-73...
Page 126 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK <CHIP CONDUCTOR> Q6612 8-729-029-66 TRANSISTOR DTC114ESA-TP Q6613...
Page 127 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R6625 1-208-826-11 METAL CHIP 0.5% 1/10W R6692...
Page 128 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. D DH REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R6846 1-260-127-11 CARBON 220K 1/2W...
Page 129 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK <IC> C6104 1-126-965-11 ELECT 22UF 20.00%50V C6105...
Page 130 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C6409 1-126-963-11 ELECT 4.7UF 20.00%50V JR6111 1-216-296-91...
Page 131 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R6123 1-208-782-11 METAL CHIP 0.5% 1/10W R6202...
Page 132 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK <VARIABLE RESISTOR> C4357 1-164-004-11 CERAMIC CHIP 0.1UF 10.00%25V...
Page 133 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK D4804 8-719-911-19 DIODE 1SS119-25TD Q4800 8-729-230-49 TRANSISTOR 2SC2712-YG-TE85L...
Page 134 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R4334 1-216-049-91 RES-CHIP 1/10W R4519 1-216-073-00 RES-CHIP...
Page 135 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R4857 1-208-810-11 METAL CHIP 0.5% 1/10W <DIODE>...
Page 136 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK <RESISTOR> C5415 1-104-999-11 MYLAR 0.1UF 10.00%200V C5418...
Page 137 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R5409 1-247-815-91 CARBON 1/4W R1935 1-247-807-31 CARBON...
Page 138 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK C8305 1-163-133-00 CERAMIC CHIP 470PF 5.00% 50V...
Page 139 DIODE MA111-TX IC8311 8-759-485-79 IC TC7SET08FU(TE85R) D8102 1-216-295-91 SHORT IC8312 8-759-485-79 IC TC7SET08FU(TE85R) D8301 8-719-158-35 DIODE RD9.1SB-T1 IC8314 8-742-175-00 HYB IC SBX3005-11 (KV-ES34M61) D8302 8-719-158-35 DIODE RD9.1SB-T1 D8303 8-719-158-35 DIODE RD9.1SB-T1 <JACK> D8304 8-719-158-35 DIODE RD9.1SB-T1 D8305 8-719-158-35 DIODE RD9.1SB-T1 J8106...
Page 140 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK <TRANSISTOR> Q8466 8-729-230-49 TRANSISTOR 2SC2712-YG-TE85L Q8512 8-729-026-49...
Page 141 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R8348 1-216-057-00 RES-CHIP 2.2K 1/10W R8407 1-216-033-00...
Page 142 1-216-049-91 RES-CHIP 1/10W R8589 1-216-041-00 RES-CHIP 1/10W R8503 1-216-097-91 RES-CHIP 100K 1/10W R8590 1-216-041-00 RES-CHIP 1/10W R8592 1-216-295-91 SHORT 0 (KV-ES34M61) R8504 1-216-295-91 SHORT R8594 1-216-295-91 SHORT 0 (KV-ES34M61) R8507 1-216-025-91 RES-CHIP 1/10W R8595 1-216-041-00 RES-CHIP 1/10W R8508 1-216-025-91 RES-CHIP...
Page 143 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. V VM REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK R1807 1-208-816-11 METAL CHIP 0.5% 1/10W...
Page 144 8-729-045-05 TRANSISTOR 2SA2005 1-419-295-11 COIL, LANDING CORRECTION Q5407 8-729-045-04 TRANSISTOR 2SC5511 1-900-251-82 LEAD ASSY, G2 (Location CN6810 - CN9007(1)) ! 8-735-063-05 PICTURE TUBE (A80LNH10X) (KV-ES34M61) <RESISTOR> ! 8-735-062-05 PICTURE TUBE (A80LNH10X) (KV-ES34N90) 8-453-007-31 NA324-M3 R1911 1-249-411-11 CARBON 1/4W ! 8-451-500-31...
Page 145 KV-ES34M61/ES34N90 RM-916 RM-958 The components identified by shading and mark ! are critical for safety. Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK 4-076-297-01 CUSHION (LOWER) (ASSY) (Thailand) ACCESSORIES AND PACKING MATERIALS...
Page 146 Replace only with part number specified. REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK Sony Corporation English 2000AG70043-1 Sony Technology Malaysia Sdn. Bhd. Printed in Malaysia  9-965-795-01 TV Business of General Area 2000. 1 – 254 –...

This manual is also suitable for:

Trinitron kv-es34n90

Sony Trinitron KV-ES34M61 Service Manual

Self Diagnosis Function

3 Service Jig

4 Set-Up Adjustments

5 Circuit Adjustments

6 Diagrams

7 Exploded Views

8 Electrical Parts List

Quick Links

SERVICE MANUAL

Related Manuals for Sony Trinitron KV-ES34M61

Summary of Contents for Sony Trinitron KV-ES34M61

This manual is also suitable for:

Table of Contents