Page 1 January 2000 This manual supports: ThinkPad 570 (MT 2643/2644) ThinkPad 570E (MT 2643/2644)
Page 2 IBM products, programming, or services in your country. Requests for technical information about IBM products should be made to your IBM authorized dealer or your IBM marketing representative.  Copyright International Business Machines Corporation 2000. All rights reserved. Note to U.S.
Page 3: Table Of Contents
....61 1070 Modem card ....62  Copyright IBM Corp. 2000 ...
Page 4 1080 Frame and power switch ..63 1090 Audio card ....65 1100 Modem jack ....66 1110 Speaker .
Page 5: Introduction
Advise customers to contact the PC Company HelpCenter at 800-772-2227 if they need assistance in obtaining or installing any diskette fixes. Customers in Canada should call IBM HelpPC at 800-565-3344 for assistance or down-load information. The Canadian BBS phone numbers are:...
Page 6: How To Use Error Messages
Attention A customized setup configuration (other than default settings) may exist on the computer you are servicing. Running Automatic Configuration may alter those settings. Note the current configuration settings (using the View Configuration option) and verify that the settings are in place when service is complete. Hard Disk Drive Replacement Strategy: Always try to run a low-level format before replacing a hard disk drive.
Page 7: Drive And Diskette Compatibility Matrix
Drive and Diskette Compatibility Matrix The following table provides identification information for 3.5-inch drives. Diskette Identifying Drive Mark 3.5-Inch - 1.44MB 1.44 on the eject button 3.5-Inch - 2.88MB 2.88 on the eject button The following table provides compatibility information for 3.5-inch diskettes and 3.5-inch diskette drives.
Page 8: Safety Notices (Multi-Lingual Translations)
Safety Notices (Multi-lingual Translations) In this manual, safety notices appear in English with a page number reference to the appropriate multi-lingual, translated safety notice found in this section. The following safety notices are provided in English, French, German, Italian, and Spanish languages. Safety Notice 1 Before the computer is powered-on after FRU replacement, make sure all screws, springs, or other...
Page 9 Die Bereitschaftsbatterie, die sich unter dem Diskettenlaufwerk befindet, kann geringe Mengen Nickel und Cadmium enthalten. Sie darf nur durch die Verkaufsstelle oder den IBM Kundendienst ausgetauscht werden. Sie darf nicht zerlegt, wiederaufgeladen, kurzgeschlossen, oder Feuer oder Wasser ausgesetzt werden. Die Batterie kann schwere Verbrennungen oder Verätzungen...
Page 10 Safety Notice 3 The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack.
Page 11 Safety Notice 4 The lithium battery can cause a fire, explosion, or severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations.
Page 12 Safety Notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing.
Page 13 Safety Notice 6 To avoid shock, do not remove the plastic cover that surrounds the lower portion of the inverter card. Afin d'éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d'alimentation. Aus Sicherheitsgründen die Kunststoffabdeckung, die den unteren Teil der Spannungswandlerplatine umgibt, nicht entfernen.
Page 14 Safety Notice 8 Before removing any FRU, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d'alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d'interface.
Page 15: Safety Information
Safety Information The following section contains the safety information that you need to be familiar with before servicing an IBM mobile computer. General Safety Follow these rules to ensure general safety: Observe good housekeeping in the area of the machines during and after maintenance.
Page 16: Electrical Safety
Electrical Safety Observe the following rules when working on electrical equipment. Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges.
Page 17: Safety Inspection Guide
This guide addresses only those items. However, good judgment should be used to identify potential safety hazards due to attachment of non-IBM features or options not covered by this inspection guide. If any unsafe conditions are present, you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem.
Page 18 Insulation must not be frayed or worn. 4. Remove the cover. 5. Check for any obvious non-IBM alterations. Use good judgment as to the safety of any non-IBM alterations. 6. Check inside the unit for any obvious unsafe conditions, such as metal filings, contamination, water or other liquids, or signs of fire or smoke damage.
Page 19: Handling Electrostatic Discharge-Sensitive Devices
Handling Electrostatic Discharge-Sensitive Devices Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD). ESD damage can occur when there is a difference in charge between objects. Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same charge.
Page 20: Laser Compliance Statement
Laser compliance statement Some IBM Personal Computer models are equipped from the factory with a CD-ROM drive. CD-ROM drives are also sold separately as options. The CD-ROM drive is a laser product. The CD-ROM drive is certified in the U.S. to...
Page 21 El uso de controles o ajustes o la ejecución de procedimientos distintos de los aquí especificados puede provocar la exposición a radiaciones peligrosas. Opening the CD-ROM drive could result in exposure to hazardous laser radiation. There are no serviceable parts inside the CD-ROM drive.
Page 22 ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 23: General Descriptions
1. Name and phone number of servicer 2. Date of service 3. Date on which the machine failed 4. Date of purchase 5. Failure symptoms, error codes appearing on the display, and beep symptoms  Copyright IBM Corp. 2000 Read this first...
Page 24 Read this first 6. Procedure index and page number in which the failing FRU was detected 7. Failing FRU name and part number 8. Machine type, model number, and serial number 9. Customer's name and address Before checking problems with the computer, determine whether the damage is covered under the warranty by referring to the following: Note for warranty...
Page 25 Important The following symptoms might indicate damage caused by nonwarranted activities: Missing parts might be a symptom of unauthorized service or modification. Hard disk drive spindles can become noisy from being subjected to excessive force or from being dropped. I9990303 errors can be caused by exposure to strong magnetic fields.
Page 26: Related Service Information
Related service information Related service information This section provides information about the following: “Reset switch” “Service Web site” “Passwords” Power management features Reset switch The Reset switch resets the system (regardless of the microcode status) and forces the power off. Use this pushbutton to power off when power is not completely off or the microcode is in a hung state.
Page 27 Related service information Supervisor and hard disk passwords: supervisor password (PAP) and the hard disk password (HDP) are security features that are used to protect the system and the hard disk data from unauthorized access. No overriding capability is provided. If only a hard disk password is set, you must get the password from its owner in order to run diagnostic tests and perform service.
Page 28: Power Management Features
Related service information Power management features To reduce power consumption, the computer has three power management modes: standby, suspend, and hibernation. Standby mode: In standby mode, the following occurs: The LCD backlight turns off. The hard disk drive motor stops. The speaker is muted.
Page 29 Related service information the power-saving mode. This default low-battery behavior is independent of the operating system: so if you have set the low-battery alarm, the computer may not do what you specified. It chooses either your setting or the default setting, whichever is appropriate.
Page 30 Related service information The timer conditions are satisfied in suspend mode (for operating systems other than Windows 98). A critically low battery condition occurs and the mode is set to Hibernate when battery becomes low. When the power is turned on, the computer leaves hibernation mode and resumes operation.
Page 31: Checkout Guide
Use the following procedures as a guide in identifying and correcting problems with the ThinkPad computer. Note: The diagnostic tests are intended to test only IBM products. The use of non-IBM products, prototype cards, or modified options can lead to false indications of errors and invalid system responses.
Page 32: Detecting System Information With Pc-Doctor
Checkout guide The options on the test menu are as follows: Diagnostics Interactive Tests Run Normal Test Keyboard Run Quick Test Video CPU/Coprocessor Internal Speaker Systemboard Mouse Video Adapter Joystick Serial Ports Diskette Fixed Disks System Load Diskette Drives CD-ROM/DVD Other Devices Stereo Speaker Memory Test –...
Page 33: Power System Checkout
VGA Information IDE Drive Info PCI Information PNPISA Info SMBIOS Info FRU Info Utility: Run External Tests Surface Scan Hard Disk Benchmark System DOS Shell Tech Support Form Battery Rundown View Test Log Print Log Save Log Full Erase Hard Drive Quick Erase Hard Drive Power system checkout To verify the symptom of a problem, do the following:...
Page 34 Checkout guide (16 - 10 V) Voltage (V dc) +15.5 to +17.0 Ground If the voltage is not correct, replace the ac adapter. If the voltage is acceptable, do the following: Replace the system board. If the problem persists, go to “Product overview” on page 35.
Page 35 Terminal Voltage (V dc) + 0 to + 12.6 Ground (−) 3. If the voltage is less than +11.0 V dc, the battery pack has been discharged. Recharge the battery pack. Note: It takes at least 3 hours to recharge the battery pack.
Page 36 Checkout guide If the voltage is correct, replace the system board. If the voltage is not correct, replace the backup battery. If the backup battery discharges quickly after replacement, replace the system board. ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 37: Thinkpad 570 And 570E
....98 Parts List ..... 99  Copyright IBM Corp. 2000 . . . 82...
Page 38 ThinkPad 570 and 570E LCD FRU ....Keyboard ....Common Parts List .
Page 39: Product Overview
Product overview Product overview This section describes the following product-unique information: “Specifications” “Status indicators” on page 37 “Structure” on page 38 “Fn key combinations” on page 41 Specifications The following table lists the specifications of the ThinkPad 570 series: Feature Description Processor Mobile Pentium...
Page 40 Product overview Feature Description Video 12.1-inch, 16M colors SVGA (800×600 resolution) TFT color LCD 13.3-inch, 16M colors, XGA (1024×768 resolution) TFT color LCD 570E 13.3-inch, 16M colors, XGA (1024×768 resolution) TFT color LCD Diskette drive 1.44 MB (3-mode), 3.5-inch (external) Hard disk drive 4.0 GB, 2.5-inch, IDE interface...
Page 41: Status Indicators
Product overview Status indicators The system status indicators show the current computer status in different colors (green or orange): Symbol Color Meaning 1 Battery Green The battery is fully charged. Orange The battery is charging. Blinking The battery needs charging. orange 2 Suspend Green...
Page 42: Structure
Product overview Structure The following illustration shows the overall organization if the FRUs. ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 43 Product overview The following table shows the test for each FRU. Applicable test System 1. Diagnostics --> board CPU/Coprocessor 2. Diagnostics --> Systemboard Power Diagnostics --> Battery LCD unit 1. Diagnostics --> Video Adapter 2. Interactive Tests --> Video Modem 1.
Page 44 Product overview Applicable test Diskette 1. Diagnostics --> Diskette Drive drive 2. Interactive Tests --> Diskette CD-ROM Interactive Tests --> CD-ROM/DVD or DVD drive (in UltraBase) Joystick Interactive Tests --> Joystick Memory 1. If a DIMM is installed, remove it and run Memory Test - Quick (Diagnostics).
Page 45: Fn Key Combinations
Product overview Fn key combinations The following table shows the function of each combination of Fn with a function key. The Fn key works independently from the operating system. The operating system obtains the status through the system management interface to control the system. Description combination Fn + F1...
Page 46: Symptom-To-Fru Index
If the symptom is not described there, go to “Intermittent problems” on page 46. Note For IBM devices not supported by diagnostic codes in the ThinkPad notebook computers, see the manual for that device. Numeric error codes...
Page 47 Symptom-to-FRU index Symptom or error FRU or action, in sequence 0220 1. Load Setup Defaults Monitor type does not match in IBM BIOS Setup CMOS Utility. 0230 1. System board. Shadow RAM failure at offset nnnn 0231 1. DIMM. System RAM failure at 2.
Page 48: Error Messages
Error messages Symptom or error FRU or action, in sequence Device address conflict 1. Load Setup Defaults in IBM BIOS Setup Utility. 2. Backup battery. 3. System board. Allocation error for: device 1. Load Setup Defaults in IBM BIOS Setup Utility.
Page 49: Beep Symptoms
Symptom-to-FRU index Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, 1. Reseat the LCD unreadable, or flashing LCD connector 2. LCD assembly 3. System board One long and two short 1. System board. beeps, and a blank or 2.
Page 50: Intermittent Problems
Symptom-to-FRU index Symptom or error FRU or action, in sequence No beep, power-on indicator 1. System board. on, and a blank LCD during POST LCD backlight not 1. Reseat the LCD working connectors.. 2. LCD assembly. LCD too dark 3. System board. LCD brightness cannot be adjusted LCD contrast cannot...
Page 51 Symptom-to-FRU index 3. Remove or disconnect all of the following devices: a. Non-IBM devices b. Devices attached to the port replicator c. Printer, mouse, and other external devices d. Battery pack e. Hard disk drive f. External diskette drive g. DIMM h.
Page 52: Fru Replacement Notices
This section contains notices for removal and replacement. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. The an IBM ThinkPad computer address this problem with special nylon-coated screws that have the following characteristics: They maintain tight connections.
Page 53: Retaining Serial Numbers
FRU replacement notices torque shown in the table. Never use a screw that you removed. Use a new one. Make sure the screws are tightened firmly Retaining serial numbers This section includes the following descriptions: “Restoring the serial number of the system unit” “Retaining the UUID”...
Page 54 FRU replacement notices 1. Install the ThinkPad Hardware Maintenance Diskette Version 1.60, and restart the computer. 2. Select 4. Assign UUID from the main menu. A new UUID is created and written. If a valid UUID already exists, it is not overwritten. ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 55: Removing And Replacing A Fru
Removing and replacing a FRU Removing and replacing a FRU This section presents information and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service the computer unless you have been trained and certified.
Page 56 Removing and replacing a FRU Attention The system board is sensitive to, and can be damaged by, electrostatic discharge. Establish personal grounding by touching a ground point with one hand before touching these units. You must use electrostatic discharge (ESD) strap (P/N 6405959) to establish personal grounding.
Page 57: 1010 Battery Pack
Removing and replacing a FRU 1010 Battery pack ThinkPad 570 and 570E...
Page 58: 1020 Backup Battery
Removing and replacing a FRU 1020 Backup battery Safety Notice 4: Translation on page 7 The backup battery is a lithium battery and can cause a fire, an explosion, or severe burns. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water.
Page 59 Removing and replacing a FRU Cable route: ThinkPad 570 and 570E...
Page 60: 1030 Dimm
Removing and replacing a FRU 1030 DIMM Battery pack (1010) Note The ThinkPad 570E computer's DIMM slot faces in the direction opposite that shown here. However, the procedure for removing DIMM is the same. Step Screw (quantity) Not removable ThinkPad 570 and 570E Hardware Maintenance...
Page 61: 1040 Hard Disk Drive
Removing and replacing a FRU 1040 Hard disk drive Attention Do not drop or apply any shock to the hard disk drive. The hard disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data. Before removing the drive, have the user make a backup copy of all the information on the drive if possible.
Page 62 Removing and replacing a FRU When removing the hard disk drive, open the LCD a little as shown in the figure. Attention Be careful not to drop the hard disk drive. It is still attached to the cover when you push it up. ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 63: 1050 Keyboard
Removing and replacing a FRU 1050 Keyboard Battery pack (1010) Hard disk drive (1040) Step Screw (quantity) M2.5 x 9 mm (3) (continued) ThinkPad 570 and 570E Torque 4 kgcm...
Page 64 Removing and replacing a FRU ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 65: 1060 Center Cover
Removing and replacing a FRU 1060 Center cover Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Step Screw (quantity) M2.5 x 3 mm (2) M2.5 x 9 mm (1) M2.5 x 9 mm (1) ThinkPad 570 and 570E Torque 4 kgcm 4 kgcm 4 kgcm...
Page 66: 1070 Modem Card
Removing and replacing a FRU 1070 Modem card Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 67: 1080 Frame And Power Switch
Removing and replacing a FRU 1080 Frame and power switch Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Step Screw (quantity) M2.5 x 3 mm (4) (continued) ThinkPad 570 and 570E Torque 4 kgcm...
Page 68 Removing and replacing a FRU Step Screw (quantity) M2.5 x 4.8 mm (4) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm...
Page 69: 1090 Audio Card
Removing and replacing a FRU 1090 Audio card Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Step Screw (quantity) M2.5 x 4.8 mm (1) ThinkPad 570 and 570E Torque 4 kgcm...
Page 70: 1100 Modem Jack
Removing and replacing a FRU 1100 Modem jack Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) Step Screw (quantity) M2.5 x 4.8 mm (1) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm...
Page 71: 1110 Speaker
Removing and replacing a FRU 1110 Speaker Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) For the ThinkPad 570 computer Step Screw (quantity) M2.5 x 4.8 mm (2) (continued) ThinkPad 570 and 570E Torque...
Page 72 Removing and replacing a FRU For the ThinkPad 570E computer ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 73: 1120 Audio Cable
Removing and replacing a FRU 1120 Audio cable Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) When replacing: Make sure you install the cable in the correct direction.
Page 74: 1130 Pc Card Slots
Removing and replacing a FRU 1130 PC Card slots Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Step Screw (quantity) M2.5 x 4.8 mm (1) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm...
Page 75: 1140 Hard Disk Drive Cable
Removing and replacing a FRU 1140 Hard disk drive cable Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) For the ThinkPad 570 computer Step Screw (quantity) M2.5 x 4.8 mm (2) (continued) ThinkPad 570 and 570E Torque...
Page 76 Removing and replacing a FRU For the ThinkPad 570E computer Step Screw (quantity) M2.5 x 4.8 mm (2) (continued) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm...
Page 77 Removing and replacing a FRU When replacing: If the cable and cable shield are not installed correctly, they might be in the way when you install the hard disk drive. To install them correctly, do as follows: 1. Insert the tab of the cable 1 and catch the cable shield by the base cover latches 2 .
Page 78: 1150 Upper Shield
Removing and replacing a FRU 1150 Upper shield Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Step Screw (quantity) M2.5 x 4.8 mm (3) M2 x 9 mm (4) (continued) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm...
Page 79 Removing and replacing a FRU For the ThinkPad 570 computer Step Screw (quantity) M2.5 x 4.8 mm (3) M2 x 9 mm (3) kgcm (continued) ThinkPad 570 and 570E Torque 4 kgcm Yellow...
Page 80 Removing and replacing a FRU For the ThinkPad 570E computer Step Screw (quantity) M2 x 9 mm (3) M2.5 x 4.8 mm (1) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm 4 kgcm...
Page 81: 1160 Fan
Removing and replacing a FRU 1160 Fan Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Upper shield (1150) For the ThinkPad 570 computer Note: Do not pinch the fan cable when re-installing the fan.
Page 82 Removing and replacing a FRU For the ThinkPad 570E computer Step Screw (quantity) M2.5 x 4.8 mm (2) When replacing: 1. Make sure not to pinch the fan cable when re-installing the fan. 2. Apply grease to the underside of the surface shown in...
Page 83: 1170 Lcd Unit
Removing and replacing a FRU 1170 LCD unit Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Step Screw (quantity) M2.5 x 4.8 mm (4) (continued) ThinkPad 570 and 570E Torque 4 kgcm...
Page 84 Removing and replacing a FRU Step Screw (quantity) M2 x 9 mm (1) M2.5 x 4.8 mm (1) M2.5 x 4.8 mm (2) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm 4 kgcm 4 kgcm...
Page 85: 1180 System Board Assembly
Removing and replacing a FRU 1180 System board assembly Battery pack (1010) Backup battery (1020) DIMM (1030) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) Modem jack (1100) Speaker (1110) Audio cable (1120) PC Card slots (1130)
Page 86: 1190 I/O Connector Cable Or System Board
Removing and replacing a FRU 1190 I/O Connector cable or system board Battery pack (1010) Backup battery (1020) DIMM (1030) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) Modem jack (1100) Speaker (1110) Audio cable (1120)
Page 87 Removing and replacing a FRU ThinkPad 570 and 570E...
Page 88: 2010 Lcd Front Bezel
Removing and replacing a FRU 2010 LCD front bezel Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) LCD unit (1170) CAUTION: The inverter card has a high tension current. To avoid shock hazard, never power on the computer when the LCD cover is opened.
Page 89 Removing and replacing a FRU 13.1-inch XGA TFT LCD Step Screw (quantity) M2.5 x 3 mm (2) ThinkPad 570 and 570E Torque 4 kgcm...
Page 90 Removing and replacing a FRU 12.1-inch SVGA TFT LCD Step Screw (quantity) M2.5 x 3 mm (4) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm...
Page 91: 2020 Inverter Card
Removing and replacing a FRU 2020 Inverter card Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) LCD unit (1170) LCD front bezel (2010) Note: Be careful of high voltage on the cable. Connect the LCD connector firmly to the inverter card by lifting it up straight.
Page 92: 2030 Lcd Panel
Removing and replacing a FRU 2030 LCD panel Battery pack (1010) Hard disk drive (1040) Center cover (1060) LCD unit (1170) LCD front bezel (2010) Inverter card (2020) 13.3-inch XGA TFT LCD Step Screw (quantity) M2.5 x 3 mm (2) M2.5 x 3 mm (2) (continued) ThinkPad 570 and 570E Hardware Maintenance...
Page 93 Removing and replacing a FRU Step Screw (quantity) Torque Note M2.5 x 3 mm (2) 4 kgcm Blue, Small head ThinkPad 570 and 570E...
Page 94 Removing and replacing a FRU 12.1-inch SVGA TFT LCD Step Screw (quantity) M2.5 x 3 mm (4) ThinkPad 570 and 570E Hardware Maintenance Manual Torque 4 kgcm...
Page 95: 2040 Hinges
Removing and replacing a FRU 2040 Hinges Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) LCD unit (1170) LCD front bezel (2010) Inverter card (2020) LCD panel (2030) 13.3-inch XGA TFT LCD: See “2030 LCD panel”...
Page 96: 3010 Blank Bezel In The Ultrabase
Removing and replacing a FRU 3010 Blank bezel in the UltraBase In the UltraslimBay In the diskette-drive/battery bay ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 97: Battery Pack In The Ultrabase
Removing and replacing a FRU Battery pack in the UltraBase ThinkPad 570 and 570E...
Page 98: Locations
Locations Locations Front view LCD panel Brightness control Built-in microphone External diskette drive Diskette eject button Headphone jack Line-In jack Microphone jack Reset switch PC Card slots PC Card eject button Status indicator TrackPoint Click buttons Fn Key Suspend switch ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 99 Locations ThinkPad 570 and 570E...
Page 100: Rear View
Locations Rear view Security keyhole AC Adapter jack External-diskette-drive connector Serial connector Parallel connector External-monitor connector External-input-device connector Modem connector ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 101: Bottom View
Bottom view Battery pack Battery release switch Built-in speaker Expansion connector Power switch USB port Memory slot Hard disk drive LCD latches ThinkPad 570 and 570E Locations...
Page 102: Password Pads
Locations Password pads ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 103: Parts List
Parts list Parts List ThinkPad 570 and 570E...
Page 104 Parts list The parts marked with asterisk are CRU (customer replacement unit). LCD unit (see “LCD FRU” on page 103.) Center cover, for 12.1-inch Center cover (570), for 13.3-inch Center cover (570E), for 13.3-inch Keyboard (see “Keyboard” on page 106) Keyboard bezel (570) Keyboard bezel (570E) Modem jack (RJ11)
Page 105 For 570E, MT 2643 Base cover Base cover, for Korea Base cover, for China Base cover, for Taiwan For 570E, MT 2644 Base cover Base cover, for Korea Base cover, for China Base cover, for Taiwan DIMM cover* Battery pack*, Panasonic Battery pack*, SANYO Backup battery* Holder, backup battery (see system misc.
Page 106 Parts list Screw kit (including nylon-coated screws): M2 x 4 mm, pan head (5) M2 x 9 mm, flat head (10) M2.5 x 3 mm, flat head (20) M2.5 x 4.8 mm, flat head (30) M2.5 x 9 mm, flat head (10) M2.5 x 3 mm, flat head small (5) M3 x 3 mm, flat head (5) Hex stud D-sub (10)
Page 107: Lcd Fru
Parts list LCD FRU 13.3-inch XGA TFT (continued) ThinkPad 570 and 570E...
Page 108 Parts list LCD unit (DBU) LCD unit (HITACHI) LCD rear cover kit for Korea (570) LCD rear cover kit for Korea (570E) LCD front bezel LCD panel (see LCD Unit) LCD rear cover Hinges Shield LCD cables LCD miscellaneous parts kit Inverter card Rear shield Copper tape...
Page 109: Inch Svga Tft
12.1-inch SVGA TFT LCD unit LCD rear cover kit for Korea LCD front bezel LCD panel (see LCD unit) Inverter card LCD rear cover Hinges LCD miscellaneous parts kit LCD cables ThinkPad 570 and 570E Parts list 05K9505 10L1909 05K6076 10L1248 05K6074 05K6078...
Page 110: Keyboard
Parts list Keyboard Arabic Belgian Canadian French Chinese, Simplified Chinese, Traditional Czech Danish Dutch French German Hungary Hebrew Italian Japanese Korean Latin American Spanish Norwegian Portuguese Russian Spanish Swedish or Finnish Swiss Turkish U.K. English U.S. English Option list AC adapter* (56W, Sanken) AC adapter*, for Japan AC adapter* (56W, Astec) AC adapter* (56W, Astec), for Japan...
Page 111 Modem kit for Australia for Austria for Belgium for Denmark for France for Germany for Israel for Italy for Malaysia for Netherlands for New Zealand for Norway or Finland for Portugal for Singapore for Spain for Sweden for Switzerland for Turkey for U.K.
Page 112: Common Parts List
Parts list Common Parts List Tools Triconnector wrap plug PC test card Audio wrap cable USB parallel test cable Screwdriver kit Torque screwdriver 5mm socket wrench Screwdriver ThinkPad hardware maintenance diskette version 1.60 Note: Download the file from the Web site. ThinkPad 570 and 570E Hardware Maintenance Manual 72X8546...
Page 113 Power cords: IBM power cords for a specific country are usually available only in that country: For 2-pin power cords: Used in these countries Japan Argentina For 3-pin power cords: Used in these countries Argentina People's Republic of China (other than Hong...
Page 114 Parts list ThinkPad 570 and 570E Hardware Maintenance Manual...
Page 115: Notices
Notices References in this publication to IBM products, programs, or services do not imply that IBM intends to make these available in all countries in which IBM operates. Any reference to an IBM product, program, or service is not intended to state or imply that only that IBM product, program, or service may be used.
Page 116 Part Number: 09N8609 Printed in U.S.A.

This manual is also suitable for:

Thinkpad 570 Mt 2643 Mt 2644

IBM ThinkPad 570E Hardware Manual

Introduction

General Descriptions

Thinkpad 570 and 570E

Quick Links

Related Manuals for IBM ThinkPad 570E

Summary of Contents for IBM ThinkPad 570E

This manual is also suitable for:

Table of Contents